ASSESSMENT OF DEOXYGENATION EFFICIENCY FOR WATER OF VARIOUS MINERALIZATION
DOI:
https://doi.org/10.15421/jchemtech.v31i4.287533Keywords:
corrosion, redoxite, water deoxidation, water deironing, sodium cationizationAbstract
The study of the influence of iron-containing redoxites on the efficiency of water deoxidation was carried out and described. During this study, the dependence of the efficiency of water deoxygenation on the filtration speed (from 1.50 to 7.50 m/h) was also determined. The residual content of oxygen and the content of dissolved iron in water were determined. As a result, it was shown that an increase in the filtration rate within the specified limits has a rather strong effect on the residual oxygen concentration, namely its increase from 0.30 mg/dm3 to 1.51 mg/dm3. The residual oxygen content also depends on the reaction of the medium, since an increase in the residual oxygen concentration was noted when the pH of the medium increased from 7.770 to 9.75, but the residual iron content was little dependent on these factors (in all cases it did not exceed 0.25 mg/dm3). When using columns with KU-2-8 cationite in the Na+ form in the scheme of the redox system, almost complete removal of iron ions from water and sodium cation softening of tap water was noted.
References
Jokar, S., Aghel, B., Fathi, S., Karimi, M. (2021). Removal of dissolved oxygen from industrial raw water in a microchannel. Environmental Technology & Innovation, 23, 101672. https://doi.org/10.1016/j.eti.2021.101672.
Feng, J., Wang, Z.M., Zheng, D., Song, G.L. (2021). Influence of dissolved oxygen on the corrosion of mild steel in a simulated cement pore solution under supercritical carbon dioxide. Construction and Building Materials, 311, 125270. https://doi.org/10.1016/j.conbuildmat.2021.125270
Yu, B., Li, D.Y., Grondin, A. (2013). Effects of the dissolved oxygen and slurry velocity on erosion–corrosion of carbon steel in aqueous slurries with carbon dioxide and silica sand. Wear, 302(1–2), 1609-1614. https://doi.org/10.1016/j.wear.2013.01.044.
Gomelya, М., Shabliy, Т., Shuryberko, М., Chuprova, К. (2018). Development of reagents for protection of equipment of water supply systems from scale and corrosion. Technology Audit ant Production Reserves, 5/3(43), 27–32. https://doi.org/10.15587/2312-8372.2018.147094
Stack, M., Mathew, M., Hodge, C. (2011). Micro-abrasion–corrosion interactions of Ni–Cr/WC based coatings: approaches to construction of tribo-corrosion maps for the abrasion–corrosion synergism. Electrochim. Acta, 56, 8249–8259. https://doi.org/10.1016/j.electacta.2011.06.064
Gomelya, M., Nosacheva, J., Korda, T., Potylchak, T. (2015). Assessing the efficiency of redoxites derived from a weakly acidic cationite dowex MAC-3 by IRON compounds. Eastern-European Journal of Enterprise Technologies, 5(6), 34–38. https://doi.org/10.15587/1729-4061.2015.50615
Moussallem, I., Pinnow, S., Wagner, N., Turek, T. (2012). Development of high-performance silver-based gas-diffusion electrodes for chlor-alkali electrolysis with oxygen depolarized cathodes. Chemical Engineering and Processing: Process Intensification, 52, 125–131. https://doi.org/10.1016/j.cep.2011.11.003
Bernstein, H. F. (2008). Water degassing in the networks of hot water supply. Entgasung und Wasserbehandlung in Fernwärmesystement. Euroheat and power, 37(6), 50–55.
Butler, I., Schoonen, M., Rickard, D. (1994). Removal of dissolved oxygen from water: a comparison of four common techniques. Talanta, 41, 211–215. https://doi.org/10.1016/0039-9140(94)80110-X
Martić, I., Maslarević, A., Mladenović, S., Lukić, U., Budimir, S. (2015). Water deoxygenation using hollow fiber membrane module with nitrogen as inert gas. Desalin. Water Treat., 54, 1563–1567. https://doi.org/10.1080/19443994.2014.888677
Ito, A., Yamagiwa, K., Tamura, M., Furusawa, M. (1998). Removal of dissolved oxygen using non-porous hollow-fiber membranes. J. Memb. Sci., 145, 111–117 https://doi.org/10.1016/S0376-7388(98)00068-4
Garudachari, B., Al-Odwani, A., Alambi, R.K., Al-Tabtabaei, M., Al-Foudari, Y., (2020). Development of carbon nanotube membranes for dissolved gases removal as seawater pretreatment. Desalination and Water Treatment, 208, 104–109. https://doi.org/10.5004/dwt.2020.26465
Garudachari, B., Al-Odwani, A., Kumar, R., Al-Tabtabaei, M., Al-Rughaib, M. (2021). Membrane degasification for desalination industries: a literature review. Desalination and Water Treatment, 238, 28–37. doi: 10.5004/dwt.2021.27821.
Shao, J., Liu, H., He, Y. (2007). Boiler feed water deoxygenation using hollow fiber membrane contactor. Desalination, 234(1–3), 370–377. https://doi.org/10.1016/j.desal.2007.09.106.
Li, T., Yu, P., Luo, Y., (2014). Preparation and properties of hydrophobic poly (vinylidene fluoride)–SiO2 mixed matrix membranes for dissolved oxygen removal from water. Journal of applied polymer science, 131, 40430. https://doi.org/10.1002/app.40430
Jincai, Su, Yanyan, Wei (2019). Novel tri-bore PVDF hollow fiber membranes for the control of dissolved oxygen in aquaculture water. Journal of Water Process Engineering, 30, 100584. https://doi.org/10.1016/j.jwpe.2018.02.019
Medvedev, R., Merdukh, S. (2013). Water - chemical mode and mathematical modeling of the second contour of a nuclear power plant with a type of reactor WWPR – 1000. Naukovi visti NTUU KPI,3, 132–139.
Wang, Y., Du, Ch., Yan, Z., Duan, W., Deng, J., Luo, G. (2022). Fast deoxygenation in a miniaturized annular centrifugal device. Separation and Purification Technology, 297, 121546, https://doi.org/10.1016/j.seppur.2022.121546.
Zhao, Z., Song, Y., Chen, J., Chu, G., Shao, L. (2017). Study of water deoxygenation using a rotor-stator reactor. Journal of Beijing University of Chemical Technology (Natural Science Edition), 44(1)., 13–17. https://doi.org/10.13543/j.bhxbzr.2017.01.003
Homelia, M., Shabliy, T., Tsveniuk, V., Shuryberko, M. (2017). Study of the sorption and desorption processes of sulfites on the anion-exchange redoxites, Eastern-European Journal of Enterprise Technologies, 6/6(90), 47–52. https://doi.org/10.15587/1729-4061.2017.118369
Tamazashvili, A., Makarenko, I. (2015). Evalation of the reducing ability of anion exchange resin AV-17-8 in the sulphite form. Chemistry & chemical technology, 1, 91–94. https://doi.org/10.15587/1729-4061.2012.4038
Zhao Z., Wang J., Sun B., Arowo M., Shao L. (2018). Mass transfer study of water deoxygenation in a rotor–stator reactor based on principal component regression method. Chemical Engineering Research and Design, 132, 677–685. https://doi.org/10.1016/j.cherd.2018.02.007.
Lafontaine, Y., Despatie, S. (2014). Performance of a biological deoxygenation process for ships ballast water treatment under very cold water conditions, Science of The Total Environment, 472, 1036–1043. https://doi.org/10.1016/j.scitotenv.2013.11.116
Homelia, M., Korda, T., Shuryberko, M. (2016). Evaluation of the corrosiveness of water and stability with respect to scale formation. «Problems of ecology and energy saving in shipbuilding»: ХІ International Science Technology Conference, 95–97.
Karimi, A., Mahdizadeh, F., Salari, D., Niaei, A. (2011). Bio-deoxygenation of water using glucose oxidase immobilized in mesoporous MnO2. Desalination, 275(1-3) 148–153 https://doi.org/10.1016/j.desal.2011.02.053
Troiatskyi, M., Bykov S. (2007). The method of obtaining filter material: pat. 26988 Ukraine: IPC: BOIJ 20/30, BOIJ 20/20. № u200706648. Troiatskyi, M. V., Bykov S. V. (2007). Ukraine Patent No. 26988 U. Kyiv, Ukraine.
Troiatskyi, M., Masalitin, V., Homelia, M., (2010). The method of obtaining filter material for filters designed for water deoxygenation: pat. 89903 Ukraine: IPC: BOIJ 20/20, BOIJ 20/30, Е03В 3/00, ВОІD 39/16. № а200811234. Troiatskyi, M. V., Masalitin, V. M., Homelia, M. D. (2010). Ukraine Patent No. 89903. Kyiv, Ukraine.
Moon, J.S., Park, K.K., Seo, G., Song H.R. (2002) Dissolved oxygen removal method using activated carbon fiber and apparatus thereof: Pat. 6391256 USA, 21. 9. Moon, J. S., Park, K. K., Seo, G., Song, H.R. (2002). US Patent No. 6391256.
Mahdizadeh, F., Eskandarian, M. (2014). Glucose oxidase and catalase co-immobilization on biosynthesized nanoporous SiO2 for removal of dissolved oxygen in water: Corrosion controlling of boilers. Journal of Industrial and Engineering Chemistry, 20(4), 2378–2383, https://doi.org/10.1016/j.jiec.2013.10.016.
Xia, Z., YaBin, L., Hao, X., XiaoChun, W., ZhongLin, Ch. (2017). Effect of dissolved oxygen concentrations on the operational efficiency of the powdered activated carbon-membrane bioreactor (PAC-MBR) and single membrane bioreactor (MBR). Desalination and Water Treatment, 93, 22–29. https://doi.org/10.5004/dwt.2017.21460
Porzhezinskyi, U. (2020). New technological solutions for the preparation of water for hot water boilers and thermal systems. Naukovi pratsi NUKhT, 26(1), 91–97. https://doi.org/10.24263/2225-2924-2020-26-1-12
Remeshevska, I., Trokhymenko, G., Gurets, N., Stepova, O., Trus, I., Akhmedova, V. (2021). Study of the ways and methods of searching water leaks in water supply networks of the settlements of Ukraine. Ecological Engineering and Environmental Technology, 22(4), 14–21. https://doi.org/10.12912/27197050/137874
Trus, I., Radovenchyk, I., Halysh, V., Skiba, M., Vasylenko, I., Vorobyova, V., Hlushko, O., Sirenko, L. (2019). Innovative approach in creation of integrated technology of desalination of mineralized water. Journal of Ecological Engineering, 20(8), 107–113. doi:10.12911/22998993/110767
Trus, I., Gomelya, N., Halysh, V., Radovenchyk, I., Stepova, O., Levytska, O. (2020). Technology of the comprehensive desalination of wastewater from mines. Eastern-European Journal of Enterprise Technologies, 3(6-105), 21–27. https://doi.org/10.15587/1729-4061.2020.206443
Downloads
Published
Issue
Section
License
Copyright (c) 2023 Oles Honchar Dnipro National University
This work is licensed under a Creative Commons Attribution 4.0 International License.
- Authors reserve the right of attribution for the submitted manuscript, while transferring to the Journal the right to publish the article under the Creative Commons Attribution License. This license allows free distribution of the published work under the condition of proper attribution of the original authors and the initial publication source (i.e. the Journal)
- Authors have the right to enter into separate agreements for additional non-exclusive distribution of the work in the form it was published in the Journal (such as publishing the article on the institutional website or as a part of a monograph), provided the original publication in this Journal is properly referenced
- The Journal allows and encourages online publication of the manuscripts (such as on personal web pages), even when such a manuscript is still under editorial consideration, since it allows for a productive scientific discussion and better citation dynamics (see The Effect of Open Access).
